BREWER CO -- PLASTIC ROOF CEMENT  -- 5610-00N057698
<pre>=====================  Product Identification  =====================

Product ID:PLASTIC ROOF CEMENT
MSDS Date:01/01/1992
FSC:5610
NIIN:00N057698
=== Responsible Party ===
Company Name:BREWER CO
Address:1354 U S HWY 50
City:MILFORD
State:OH
ZIP:45150
Country:US
Info Phone Num:614-279-8688
Emergency Phone Num:513-576-6300
CAGE:BREWE
=== Contractor Identification ===
Company Name:BREWER CO
Box:UNKNOW
CAGE:3V940
Company Name:BREWER CO
Address:1354 U S HWY 50
City:MILFORD
State:OH
ZIP:45150
Country:US
Phone:513-576-6300
CAGE:BREWE

=============  Composition/Information on Ingredients  =============

Ingred Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: <55%
OSHA PEL:N/K 
ACGIH TLV:5 MG/M3; (FUME)

Ingred Name:CALCIUM CARBONATE
CAS:1317-65-3
RTECS #:EV9580000
Fraction by Wt: <30%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST

Ingred Name:MINERAL SPIRITS. BP:300F, 149C. VP:2.9. VAP DENS:4.9 (ING
    4)
CAS:64742-88-7
Fraction by Wt: <25%
OSHA PEL:N/K 
ACGIH TLV:100 PPM (MFR)

Ingred Name:ING 3:EVAP RATE:70 (ETHYL ETHER =1). FL PT:100F,38C.
    METH:TCC. LEL:0.9%. UEL:6.7%
RTECS #:9999999ZZ

Ingred Name:CELLULOSE
CAS:9004-34-6
RTECS #:FJ5691460
Fraction by Wt: <10%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3

Ingred Name:SILICA, AMORPHOUS, DIATOMACEOUS EARTH; (SILICEOUS EARTH)
CAS:61790-53-2
RTECS #:HL8600000
Fraction by Wt: <10%
OSHA PEL:20 MPPCF; Z-3
ACGIH TLV:10 MG/M3 TDUST

Ingred Name:MAGNESIUM CARBONATE
CAS:546-93-0
RTECS #:OM2470000
Fraction by Wt: <5%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST

Ingred Name:SUPDAT:MAY LEAD TO IRRIT & DERM. IN LAB ANIMAL STUDIES,
    PRLNGD & RPTD INHAL EXPOS TO HYDROCARBON VAPS SIMILAR (ING 9)
RTECS #:9999999ZZ

Ingred Name:ING 8:TO MINERAL SPIRITS HAVE RSLTD IN KIDNEY AFFECTS IN
    MALE RATS. IMPLICATIONS OF THESE RSLTS FOR HUMANS HAVE (ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 9:NOT YET BEEN DETERM. THIS PETRO BASED PROD CONTAINS
    SM AMTS OF POLYCYCLIC AROMTIC HYDROCARBONS WHICH HAVE (ING 11)
RTECS #:9999999ZZ

Ingred Name:ING 10:BEEN SHOWN TO CAUSE CANCER & RESP DMG IN LAB
    ANIMALS.
RTECS #:9999999ZZ

Ingred Name:FIRST AID PROC:INDUCE VOMIT-TRANSPORT TO HOSPITAL IMMED.
    GET MED ATTN IMMED. NOTE TO PHYS:PERFORM GASTRIC LAVAGE(ING 13)
RTECS #:9999999ZZ

Ingred Name:ING 12:IN ACCORDANCE WITH PROCEDURES FOR INGESTION OF
    PETROLEUM PRODUCTS.
RTECS #:9999999ZZ

Ingred Name:SPILL PROC:EXTENSIVE LAND AREAS.
RTECS #:9999999ZZ

Ingred Name:WASTE DISP METH:ARE HAZARDOUS WASTE IF NOT EMPTIED
    COMPLETELY (LESS THAN 1 INCH OF RESIDUE)
RTECS #:9999999ZZ

Ingred Name:OTHER PREC:MANNER & I/A/W GOVT REGS. "EMPTY" CNTNRS RETAIN
    RESIDUE & CAN BE DANGEROUS. DO NOT PRESSURIZE, CUT, (ING 17)
RTECS #:9999999ZZ

Ingred Name:ING 16:WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOS SUCH CNTNRS
    TO HEAT, FLAME, SPKS/OTHER SOURCES OF IGNIT. THEY MAY(ING 18)
RTECS #:9999999ZZ

Ingred Name:ING 17:EXPLODE & CAUSE INJURY/DEATH. DO NOT ATTEMPT TO
    CLEAN SINCE RESIDUE IS DFCLT TO REMOVE. FOR WORK ON (ING 19)
RTECS #:9999999ZZ

Ingred Name:ING 18:TANKS, REFER TO OSHA REG ANSI Z49.1 & OTHER GOVT &
    INDUST REFERENCES PERTAINING TO CLEANING, REPAIRING, (ING 20)
RTECS #:9999999ZZ

Ingred Name:ING 19:WELDING/OTHER CONTEMPLATED OPERATIONS. HLTH STUDIES
    HAVE SHOWN THAT INDIVIDUAL SENSITIVITIES VARY FROM (ING 21)
RTECS #:9999999ZZ

Ingred Name:ING 20:PERSON TO PERSON. AS PREC, EXPOS TO VAPS, LIQS,
    MISTS/FUMES SHOULD BE MINIMIZED. NO SMKNG/OPEN LIGHT. (ING 22)
RTECS #:9999999ZZ

Ingred Name:ING 21:KEEP CNTNRS CLSD WHEN NOT IN USE. DO NOT STORE NEAR
    HEAT, SPKS, FLAME/STRONG OXIDANTS. TO PVNT FIRE/EXPLO(ING 23)
RTECS #:9999999ZZ

Ingred Name:ING 22:RISK FROM STATIC ACCUM & DISCHARGE, EFTIVELY GROUND
    PROD TRANSFER SYS I/A/W NFPA STD FOR PETROLEUM PRODUCTS.
RTECS #:9999999ZZ

Ingred Name:VENT:PROOF EQUIPMENT.
RTECS #:9999999ZZ

Ingred Name:HYGIENE PRACT:REMOVE CONTAMD SHOES & THOROUGHLY CLEAN & DRY
    BEFORE REUSE.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:UPPER RESP TRACT (NOSE &
    THROAT) IRRIT. POSS CNS EFTS INCL HDCH, DIZZ, NAUS & VOMIT.
    SKIN:PRLNGD/RPTD CONT W/COLD PROD MAY RSLT IN DEFAT & DRYING OF
    SKIN WHICH MAY LEAD TO IRRIT & DERM. CO NT W/HOT PROD WILL CAUSE
    THERM BURNS. SKIN CONT W/CLTHG SATURATED W/MINERAL SPIRITS CAN
    CAUSE SECOND (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:DEGREE BURNS. INGEST:MAY CAUSE MOUTH,
    THROAT, & GI TRACT IRRIT, NAUS, VOMIT & DIARR. ASPIR OF MINERAL
    SPIRITS PORTION OF THIS PROD INTO LUNGS CAN CAUSE SEV CHEM PNEUM
    WHICH MAY BE FATAL. CHRO NIC:THERE ARE NO STUDIES TO INDICATE THAT
    EXPOS TO ASPHALT CAUSES CANCER/RESP DMG IN MAN. HOWEVER, THIS PETRO
    (SUPDAT)
Medical Cond Aggravated by Exposure:PERSONS WITH A HISTORY OF CHRONIC
    SKIN OR RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FOR
    WORSENING THEIR CONDITIONS FROM EXPOSURE TO THIS PRODUCT.

=======================  First Aid Measures  =======================

First Aid:EYE CONT:FLUSH W/LG AMTS OF WATER FOR @ LST 15 MINS. GET MED
    ATTN. SKIN:REMOVE CONTAMD CLTHG, WIPE EXCESS MATL FROM SKIN,
    THOROUGHLY WASH EXPOSED AREA W/SOAP & WATER. IF IRRIT/REDNESS
    DEVELOPS & PERSI STS, SEEK MED ATTN. INHAL:REMOVE INDIVIDUAL TO
    FRESH AIR. IF IRRIT PERSISTS, ADMIN OXYG. IF BRTHG HAS STOPPED,
    GIVE ARTF RESP. KEEP PERSON WARM & QUIET. GET MED ATTN.
    INGEST:ASPIR HAZ. DO NOT (ING 12)

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:100F,38C
Lower Limits:0.9%
Upper Limits:6.7%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, OR WATER FOG.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . DO NOT
    DIRECT WATER ON SUBSTANCE. WATER & FOAM MAY CAUSE FROTHING. TREAT
    AS FUEL OIL FIRE. WATER MAY BE USED(SUPDAT)
Unusual Fire/Explosion Hazard:HYDROGEN SULFIDE, HIGHLY FLAMMABLE, TOXIC
    GAS, IS EMITTED FROM HEATED (>450F) ASPHALT AND MAY ACCUMULATE.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SHUT OFF & ELIM ALL IGNIT SOURCES. KEEP PEOPLE
    AWAY. RECOVER FREE PROD; ADD SAND, EARTH/OTHER SUITABLE
    ABSORBS.KEEP PROD OUT OF SEWERS & WATER COURSES BY
    DIKING/IMPOUNDING. ADVISE AUTH IF PROD HAS ENT ERED/MAY ENTER
    SEWERS, WATER COURSES OR(ING 14)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:MINIMIZE W/SKIN CONT & BRTHG VAPS.
    VENTILATE CONFINED SPACES; OPEN ALL WINDOWS & DOORS. KEEP CNTNRS
    TIGHTLY CLSD. USE PROD W/ADEQUATE VENTILATION.
Other Precautions:KEEP CNTNRS COOL, DRY & AWAY FROM SOURCES OF IGNIT.
    MATL IS COMBUST. MATL REQS ELEC GROUNDING DURING MATL TRANSFER
    PROCESS. ALL ELEC EQUIP IN STOR/HNDLG AREAS SHOULD BE INSTALLED PER
    NFPA REQUIREMENTS . DISPOSE OF IN ENVIR SAFE (ING 16)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:USE A NIOSH APPRVD AIR PURIFYING RESP W/ORGANIC
    VAPOR CARTRIDGES OR CANISTERS & A DUST/MIST PREFILTER. THE CONC OF
    H*2S EXCEEDS PEL/TLV, NIOSH APPRVD SUPPLIED AIR RESPS/SELF
    CONTAINED BREATHING APPARA TUS ARE REQD.
Ventilation:USE ONLY W/VENT SUFFICIENT TO PVNT EXCEEDING REC EXPOS
    LIMIT/BUILDUP OF EXPLO CONCS OF VAP IN AIR. USE EXPLO- (ING 24)
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
    CHEMICAL RESISTANT APRON OR OTHER IMPERVIOUS CLOTHING.
Work Hygienic Practices:MINIMIZE BRTHG VAP/MIST. AVOID PRLNGD/RPTD CONT
    W/SKIN. REMOVE CONTAMD CLTHG; LAUNDER/DRY CLEAN BEFORE REUSE. (ING
    25)
Supplemental Safety and Health
APPEAR/ODOR:HYDROCARBON ODOR. FIRE FIGHT PROC:TO COOL CLSD CNTNRS.
    CNDTNS TO AVOID:OXIDIZERS. EFTS OF OVEREXP:BASED PROD CONTAINS SM
    AMTS OF POLYCYCLIC AROMATIC HYDROCARBONS WHICH HAVE BEEN SEEN TO CA
    USE CANCER & RESP DMG IN LAB ANIMALS. PRLNGD/RPTD SKIN CONT W/THIS
    PROD MAY RSLT IN DEFAT & DRYING OF SKIN WHICH (ING 8)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:SEE ING 3
Vapor Pres:SEE ING 3
Vapor Density:SEE ING 3
Spec Gravity:>1
Evaporation Rate &amp; Reference:SEE INGREDIENT 3
Solubility in Water:NEGLIG @ 1ATM & 77F
Appearance and Odor:A BLACK THICK CONSISTENCY ASPHALT ROOF CEMENT WITH
    A SLIGHT PETROLEUM (SUPDAT)
Percent Volatiles by Volume:<30

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONT W/STRONG OXIDIZING AGENTS SUCH AS:LIQ CHLORINE, CONCENTRATED
    OXYG, SODIUM/CALCIUM HYPOCHLORITE.
Stability Condition to Avoid:AVOID ALL SOURCES OF IGNIT, INCL CNDTNS
    THAT MAY GENERATE STATIC ELEC. AVOID EXTREME TEMPS. AVOID CONT
    W/STRONG (SUPDAT)
Hazardous Decomposition Products:CARBON MONOXIDE AND DIOXIDE, OXIDES OF
    NITROGEN AND SULPHUR, HYDROCARBONS FROM COMBUSTION.

====================  Disposal Considerations  ====================

Waste Disposal Methods:ASSURE CONFORMITY W/ APPLIC FEDERAL, STATE &
    LOCAL REGS. RECOVERED MATL MAY BE INCIN IN APPRVD FACILITY. EPA HAZ
    WASTE NO:D001(IGNITABLE PER 40 CFR 260.21). THIS IS "RCRA"
    REGULATED HAZ WASTE & MUST B E DISPOSED IN PERMITTED FACILITY.
    CNTNRS (ING 15)

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.